open bonnet TATA SAFARI 2015 Owners Manual

28
D R I V I N G C O N T R O L S
1. Air bag (SRS) for driver & Horn Pad 2. Steering Wheel 3.Bonnet Opening Lever
4. Accelerator Pedal5. Brake Pedal 6. Clutch Pedal
7. Parking Brake 8. Head Lamp Leveling Switch 9 .Gear Lever
10. A.C. Control Switch 11.Operating Switches 12.Glove Box
13. Air Bag for Co-driver 14. Analog Clock 15. Air Vents
16. 4X4 Selector Switch
DRIVING CONTROLS DRIVING CONTROLSDRIVING CONTROLS DRIVING CONTROLS
DRIVING CONTROLS
ProCarManuals.com

69
PRIOR TO DRIVING
• •• •
•Opening bonnet Opening bonnetOpening bonnet Opening bonnet
Opening bonnet
• •• •
•Fuel level check Fuel level checkFuel level check Fuel level check
Fuel level check
• •• •
•Engine oil level check Engine oil level checkEngine oil level check Engine oil level check
Engine oil level check
• •• •
•Engine coolant check Engine coolant checkEngine coolant check Engine coolant check
Engine coolant check
Before you start driving you should carry out important checks on
your Safari. Please read this section carefully to know the procedure
for carrying out important checks.
ProCarManuals.com

70
P R I O R T O D R I V I N GOPENING AND CL OPENING AND CLOPENING AND CL OPENING AND CL
OPENING AND CL
OSING OSING OSING OSING
OSING
THE BONNET THE BONNETTHE BONNET THE BONNET
THE BONNET
Opening and Closing the Bonnet Opening and Closing the BonnetOpening and Closing the Bonnet Opening and Closing the Bonnet
Opening and Closing the Bonnet
1. Ensure that the vehicle is in neutral gear and apply the parking
brake. Pull the bonnet release lever located under extreme corner
of the dash board on driver’s side. The bonnet will pop up slightly.
2. Standing in front of the vehicle, lift the additional lock lever located
under the bonnet centre with a finger and lift the bonnet up. The
bonnet will rise slowly with assistance of the balancers fitted
on both corners of the bonnet.
3. To close the bonnet press down the bonnet till it is fully locked.
W WW W
W
ARNING ARNINGARNING ARNING
ARNING
Ensure that the bonnet is fully locked before driving off.
Bonnet opening lever Bonnet opening leverBonnet opening lever Bonnet opening lever
Bonnet opening lever
Additional lock lever under the bonnet centre Additional lock lever under the bonnet centreAdditional lock lever under the bonnet centre Additional lock lever under the bonnet centre
Additional lock lever under the bonnet centre
ProCarManuals.com

72
FUEL AND ENGINE OIL LEVEL CHECK FUEL AND ENGINE OIL LEVEL CHECKFUEL AND ENGINE OIL LEVEL CHECK FUEL AND ENGINE OIL LEVEL CHECK
FUEL AND ENGINE OIL LEVEL CHECK
Fuel Level Check Fuel Level CheckFuel Level Check Fuel Level Check
Fuel Level Check
1 . Check fuel level in tank. The same is indicated on the instrument
panel.
2 . If indicator is already in red zone remember to fill the fuel at
nearest filling station.
Engine Oil Level Check Engine Oil Level CheckEngine Oil Level Check Engine Oil Level Check
Engine Oil Level Check
Check engine oil level before starting the engine.
A. Open the bonnet.
B. Pull out the dipstick and wipe it with a cloth or paper towel.
C. Insert it all the way back in its tube.
D. Pull out the dipstick and look at the oil level at the end of the
dipstick.
Top up oil if the oil level is below midway of minimum mark.
NOTICE NOTICENOTICE NOTICE
NOTICE
Oil level should not exceed the max mark. Check the oil level
when vehicle is on level ground and wait for a few minutes after
switching off the engine.1. Engine Oil Filling Cap
2. Dip Stick
P R I O R T O D R I V I N G
Fuel Gauge Fuel GaugeFuel Gauge Fuel Gauge
Fuel Gauge
Low
Fuel Level
ProCarManuals.com

108
Changing of Engine Oil and Oil Filter Changing of Engine Oil and Oil FilterChanging of Engine Oil and Oil Filter Changing of Engine Oil and Oil Filter
Changing of Engine Oil and Oil Filter
Change the oil and oil filter at specified service intervals. (Engine oil and
oil filter may be changed earlier inline with recommendation given for
additional maintenance schedule under severe driving condition)
Changing of oil and oil filter requires access from underneath the vehicle.
Vehicle should be raised on a hydraulic lift of a service station or should
be on a service pit.
1 . Run the engine until it reaches normal operating temperature. Then
shut it off.
2. Remove oil sump guard.
3. Open the bonnet and remove engine oil filler cap. Remove the drain
plug of the oil sump from the bottom of the engine. Drain the oil into
an appropriate container.
4. Remove the oil filter with the help of special wrench. The removed
oil filter should not be reused and hence should be destroyed to
avoid recycling of the same. Used filter and oil should be disposed
in compliance with the current legislation.
5. Ensure cooler is tightened to it’s position.
6. Smear a little fresh engine oil on rubber gasket of new engine oil
filter. Hand tighten the engine oil filter fully and further 3/4 turn with
special tool.
Do not over tighten engine oil filter as this may damage oil filter and
oil may leak out.
7. Before filling in fresh oil in the engine, clean the drain plug..
ENGINE OIL & OIL FIL ENGINE OIL & OIL FILENGINE OIL & OIL FIL ENGINE OIL & OIL FIL
ENGINE OIL & OIL FIL
TER TERTER TER
TER
1. Engine Oil Filling Neck
2. Dip Stick
1. Oil Sump Drain Plug
2. Engine Oil Filter
M A I N T E N A N C E
2 22 2
21 11 1
1
ProCarManuals.com

146
S E R V I C E S C H E D U L ESERVICE SCHEDULE SERVICE SCHEDULESERVICE SCHEDULE SERVICE SCHEDULE
SERVICE SCHEDULE
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
GENERAL GENERALGENERAL GENERAL
GENERAL
1 Wash the vehicle & Clean the condenser with compressed air Every Service x x x x x x x x
2 Check & Top up Fluids if required: Coolant, Brake / Clutch Fluid, Battery Electrolyte, Power Every Service x x x x x x x x
Steering Oil, Gear Box Oil, Transfer Case & Front Axle (4X4) / Rear Axle Oil
3 Drain water accumulated in Sedimenter (OR Whenever warning lamp glows) Every Service x x x x x x x x
4 Check Engine Compartment for loose Fasteners, Low pressure fuel lines, Coolant hoses, air hoses, Every Service x x x x x x x x
Vacuum hoses, hydraulic line connections for leakages if any, Attend if necessary
5 Check Underbody for loose Fasteners, hydraulic line connections, Exhaust system / Fuel Pipes for Every Service x x x x x x x x
Damages / Leakages if any. Attend if necessary
6 Apply grease on door latches, door lock, door check stop, striker, bonnet opening lever & lock Every Service x x x x x x x
plate, tailgate hinges & door lock inner ratchet.
7 Check & ensure normal working of engine using Diagnostic Equipment. Every Service x x x x x x x x
2.2L DICOR ENGINE 2.2L DICOR ENGINE2.2L DICOR ENGINE 2.2L DICOR ENGINE
2.2L DICOR ENGINE
1 *Clean air cleaner filter element, Change if red band appears on service indicator even after Every Service x x x x x x x
cleaning
2 *Change engine Oil and Oil filter. Use APICH4+MB228.3 or Higher grade Engine Oil.Every Service x x x x x x x x
OR 1 Year whichever is earlier
3 Check All accessory Drive belts, adjust tension if required, change if damaged Every Service x x x x x x x
OR 1 Year whichever is earlier
4 Change fuel filterEvery Service x x x x x x x
OR 2 Years whichever is earlier
5 *Replace air filter element (OR if RED band appears on Service Indicator) 45,000 km x x
6 Change coolant in the cooling system 60,000 km x
OR 2 Years whichever is earlier
7 Change Sedimenter / Water seperator1,05,000 km x
8 Change Timing Belt & Timing Belt Idler1,05,000 km x
ProCarManuals.com

155
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
A AA A
A
Air Bags 2 2
Aggregate Numbers-Location 1 2
Air Conditioning52, 134
Air Filter & Filter Element 105
Analog Clock 66
Anti Lock Brake System 7 9
Ashtray 6 1
Audio Warning 2 1
Automatic Hub Lock 8 2
B BB B
B
Battery 118
Belt Tension 135
Bonnet Opening / Closing 7 0
Brake Fluid 115
Brakes 7 9
Branded Lubricants 9 5
C CC C
C
Catalytic Converter 132
Central Locking System 13
Child Lock 20
Cigarette Lighter 60
Clutch Fluid 115
Collapsible Steering column 2 1
Combi-Switch 33
Coolants 9 4
D DD D
D
Door Locks 20
Driving Controls 28
Driving in adverse conditions 85
Driving Safety 89
E
ECU 1 1 7
EGR System 132
Engine Compartment 104
Engine Coolant 73
Engine Cooling System 106
Engine oil 72
Engine Oil & Oil Filter 108
Environment Protection 8
F FF F
F
Flat tyre replacement 120
Follow Me Home Headlamp 64
Front & Rear Fog Lights 38
Front / Rear Axle Oil 112
Front Seat 56
Front Windshield / Door Glass Demister 5 4
Fuel 92
Fuel Economy 84
Fuel Gauge 50
Fuel level 72
Fuel Tank Flap Switch 38
Fuel Tank Flap 61
Fuses 130
G GG G
G
Gauges 4 7
Gear Box 78
Gear Box Oil 1 1 0
Gear Shift Lever 32
Glove Box 62
H HH H
H
Hazard Warning 39
Head Lamps & Headlamp Adjustment 113
Headlamp Leveling Switch 40
Headrest 57
Headrest adjustment 1 8
High mounted stop lamp 67
I II I
I
Ignition Switch 29
Immobiliser- Anti Theft Security System 31
Important Information 6,7
Indicators 43
Instrument Cluster 42
J JJ J
J
Jack & Tools 59
Jump Seats 59
ProCarManuals.com